壓縮空氣自動排水器的應用經驗

一．電子自動排水器的原理是：計時器通過控制電磁閥的得電時機間接控制閥門的開啟與閉合。

1、 The principle of the electronic automatic drainer is: the timer indirectly controls the opening and closing of the valve by controlling the power on time of the solenoid valve.

空壓機系統用戶或者服務商可以通過設置計時器上面的開關調節自動排水開啟的時長和間隔周期。

Users or service providers of air compressor system can set the switch on the timer to adjust the opening time and interval of automatic drainage.

二．物理自動排水器的原理是：靠排水器里的浮標的浮力來開啟排水器。

2、 The principle of the physical automatic drainer is that the drainer is opened by the buoyancy of the buoy in the drainer.

排水器里的液面上升，浮標上升，閥門就會(huì )自動開啟。冷凝液拍完之后，浮標恢復原位，閥門自然也隨之閉合。

When the liquid level in the drain rises and the buoy rises, the valve will open automatically. After the condensate is taken, the buoy returns to its original position and the valve naturally closes.

三．采用液位控制技術的壓縮空氣零損耗節能壓縮空氣系統冷凝液排水器，是隨著其容腔中的液面升高到電容式液位傳感器設定的高點時，傳感器給出信號，先導氣閥吸合，切斷先導氣路。此時，膜閥片上方的壓力釋放，通過液體作用于膜閥片下方的壓力將膜閥片頂離閥座，內部壓力隨之將冷凝液通過排放管排出系統之外。

3、 The condensate drainer of compressed air zero loss energy-saving compressed air system with liquid level control technology, when the liquid level in its chamber rises to the high point set by the capacitive liquid level sensor, the sensor gives a signal, the pilot gas valve closes, and the pilot gas path is cut off. At this time, the pressure above the diaphragm valve is released, and the diaphragm valve is pushed away from the valve seat by the pressure under the diaphragm valve by the liquid, and then the condensate is discharged out of the system through the discharge pipe by the internal pressure.

根據我們這么多年服務各類工礦企業用戶，接觸了N多種自動排水器之后的經驗?？梢悦鞔_地告訴您，選擇節能自動排水器重要一點就是，“三分質量，七分養護?！?/p>

According to our experience of serving all kinds of industrial and mining enterprise users for so many years and contacting N kinds of automatic drainer. Can tell you clearly, choose energy-saving automatic drainer important point is, "three points quality, seven points maintenance."

根據不同工況環境所制定的“凈化設備維護保養計劃”和其執行是否到位，決定了您自動排水器的工作狀態，運行效果和使用壽命。

According to the "purification equipment maintenance plan" formulated under different working conditions and whether its implementation is in place, it determines the working state, operation effect and service life of your automatic drainer.

即使質量再好，設計再精巧，材質再耐用的節能零氣耗自動排水器，都會(huì )因為壓縮空氣后處理凈化系統冷凝液內的固體雜質和油泥污物，使閥芯活動組件出現粘附卡連而造成排污閥口要么打不開而堵塞，要么閉合不嚴而露氣。

No matter how good the quality is, no matter how exquisite the design is, and no matter how durable the material is, the energy-saving and zero gas consumption automatic drainer will cause the solid impurities and oil sludge in the condensate of the compressed air post-treatment purification system to stick to the movable components of the valve core and cause the blowdown valve opening to be blocked, or the air will be exposed if it is not tightly closed.

所以，適時的根據自身使用情況進行自動排水器清洗，檢查，更換零部件等維護保養工作，才能讓節能壓縮空氣后處理凈化系統的自動排水器，發揮出正常功能，及時排出冷凝液，且不造成壓縮空氣損耗浪費。

Therefore, timely according to their own use of automatic drainer cleaning, inspection, replacement of parts and other maintenance work, in order to make the automatic drainer of energy-saving compressed air after-treatment purification system play a normal function, timely discharge condensate, and do not cause compressed air loss and waste.

另外，如果在安裝時，將自動排水器前端加裝功能足夠強大的過濾裝置，也能起到很好的保護作用，以保障自動排水器在相當長的使用時間內保持穩定并延長壽命。

In addition, if the front end of the automatic drainer is equipped with a powerful enough filtering device during installation, it can also play a very good role in protection, so as to ensure that the automatic drainer can remain stable for a long time and prolong its service life.